Home

RUSTECO R-200-3
RUSTECO GEL
RUSTECO NO BLAST
GREASEMASTER R-300
FEUERPRO
MATERIAL SAFETY DATA SHEET April 1, 2008
Identity: (As used on label and list)
FEUERPRO
Printable PDF of MATERIAL SAFETY DATA SHEET
SECTION I: Material & Manufacturer Identification
Product Name FEUERPRO
Material Type LIQUID
Product Use FOAM CONCENTRATE/
FIRE RETARDANT/AFFF SUBSTITUTE
Manufacturer Address RUSTECO LLC
2390 Crenshaw Blvd # 260
Torrance, CA 90501
Emergency Phone 800-787-8326
Fax 310-294-9635
E-mail rusteco@aol.com
SECTION II: Hazardous Ingredients & Identity Information
Hazard Data OSHA PEL ACGIH TLV
Based on constituent data: Oral LD50= (RAT) 1.26 g/Kg
Skin PIS (RBT) = Moderate
Eye Irritation (RBT) = Severe
Ingredients Liquid Extract from organically grown plants
Made from ingredients generally regarded as safe or permissible under CFR 21/178.1010 and CFR 21/182 respectively
DOT Hazard Class: Not Regulated
Biodegradability: Biodegradable
Corrosiveness: Non-Corrosive
SECTION III: Physical/Chemical Characteristics
Boiling Point 220 F Specific gravity (H2O = 1): 1.04
Solubility in Water Complete Specific gravity (H2O = 1): 1.04
Vapor Pressure (mm Hg) Not available Evaporation rate (Butyl Acetate = 1) : <1
Vapor Density (Air = 1) Not available Appearance and Odor: Amber, No odor
pH of 1% solution: 5-7
SECTION IV: Fire and Explosion Data
Flash Point (Methods Used) Flammable Limits LEL UEL
N/A Aqueous N/A N/A N/A
Special Fire Fighting Procedures
Wear self-contained breathing apparatus and full protective gear when entering confined areas.
Unusual Fire and Explosion Hazards
None
SECTION V: Reactivity Data
Stability Conditions to avoid
Stable under normal conditions Excessive heat
Incompatibility (Materials to avoid)
None known
Hazardous Decomposition or By-products
Thermal decomposition may produce carbon monoxide, carbon dioxide, hydrogen sulfide and oxides of sulfur.
Hazardous Polymerization Conditions to avoid
Will not occur Excessive heat
SECTION VI: Health Hazard Data
Routes of entry: Inhalation, Skin or Ingestion
Inhalation of mist, skin contact, ingestion
Health Hazards (Acute & Chronic)
Constituent Data
Skin Contact: Mildly irritating
Eyes Contact: Moderately irritating, possible corneal damage
Ingestion: Slightly toxic
Inhalation: Low volatility makes vapor inhalation unlikely
Aerosol may be irritating
Carcinogenicity: No
NTP: No
IARC Monographs: No
OSHA regulated: No
Signs and Symptoms of Exposure
Sweating, burning sensation, vomiting, nausea, shortness of breath
Medical conditions generally aggravated by exposure
Mist may cause eye or respiratory irritation with coughing
Emergency and First Aid Procedures
    (A) Eyes Immediately flush with plenty of water for 30 minutes, occasionally lifting lids. Call a physician.

    (B) Skin Remove contaminated clothing and wash contact area with soap and water for 15 minutes. If irritation persists, seek medical attention. Launder clothes before re-use.

    (C) Ingestion If appreciable quantities are swallowed call a physician or poison control center. Drink one or two glasses of water. Do not induce vomiting or give anything to an unconscious person.
SECTION VII: Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled:
Contain spill or leak to prevent discharge to the environment. Remove free liquid, soak up with inert absorbent and place in contained waste treatment system.
Waste Disposal Method
Dispose of absorbed material in accordance with all Federal, State and Local regulations. Dispose of water in contained water treatment system.
SECTION VIII: Special Protection Information
FDA/USDA/CPSC: N/A     DOT: Non-Regulated TSCA: Proprietary Mixture whose components are listed on the TSCA inventory
Proper Shipping Name: Non-Regulated     Hazardous Class: None
Label Requirements: None     ID No.: None     Other Info: N/A
EPA: Superfund Amendments & Reauthorization Act (SARA) Title III;
Section 313, Supplier Notification:


This product is known to contain the following chemicals, which are listed in 40 CFR 372.65 as toxic chemicals requiring notification:
Protective gloves: Rubber Eye protection: Safety glasses
Respiratory protection (specify type): None required under normal conditions of use

Other protective equipment: Not applicable
Ventilation: Local exhaust General Mechanical: Not applicable
SECTION IX: Spill, Leak and Disposal Procedures
Steps to be taken in case material is released or spilled:

Confine spillage and absorb on sand, sawdust or other available solids. Spills or release of this material does not currently trigger the emergency release reporting requirements under SARA Title III or CERCLA. State or local reporting requirements may differ from Federal requirements. Consult counsel for further guidance on your duties and responsibilities under these laws.

Waste Disposal Method

Dispose of absorbed material in accordance with all Federal, State and Local regulations. Dispose of water in contained water treatment system. Resource Conservation and Recovery Act (RCRA) Requirements: N/A
Chemical Name CAS # Weight Percent
Not applicable N/A N/A
SECTION IX: Control Measures/b>
Respiratory Protection (Specify Type)
Wear a properly fitting NIOSH/MSHA approved respirator
Ventilation
Local exhaust preferred
Protective Gloves
Impervious gloves to avoid contact
Eye Protection
Chemical goggles and/or full face shield as needed
Other Protective Clothing or Equipment
Wear impervious apron when splashing
SECTION XI: Special Precautions and Comments
Avoid skin and eye contact.
Ground containers when transferring from one to another.
Where dusty conditions exist, an explosive atmosphere could develop as with any organic material.

Other Precautions: Not applicable

Registration or Certifications: Not applicable
IMPORTANT NOTICE

Please read carefully prior to use
The information and data herein are believed to be accurate and have been compiled from sources to be believed to be reliable. It is offered for your consideration, investigation and verification. Buyer assumes all risk of usage, storage and handling of the product in compliance with Federal, State and Local laws and regulations. RUSTECO LLC MAKES NO WARRANTY OF ANY KIND, EXPRESS OR IMPLIED, CONCERNING THE ACCURACY OR COMPLETENESS OF THE INFORMATION AND DATA HEREIN. THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE SPECIFICALLY EXCLUDED. RUSTECO LLC will not be liable for claims relating to any party’s use of or reliance on information and data contained herein, regardless of whether it is claimed that the information and data are inaccurate, incomplete or otherwise misleading.
RUSTECO LLC, 2390 Crenshaw Blvd # 260, Torrance, CA 90501
Effective Date: 04-01-2008 ISSUE 1 FEUERPRO
Printable PDF of MATERIAL SAFETY DATA SHEET